Nixtamal pt 1

1 Servings

Ingredients

Quantity Ingredient
4 quarts Water
2 quarts Dried corn
5 tablespoons Slaked lime CaOH

Directions

Nixtamal is dried field corn soaked in, and heated in, a solution of slaked lime and water. Slaked lime, calcium hydroxide, is generally available in the form of "builder's lime" -- not to be confused with unslaked lime, calcium oxide. Unslaked lime can't be used for making nixtamal unless you slake it first by adding it to water, allowing it to bubble and then stand for a bit, and then using the WATER for processing the dried corn. It's the lime, by the way, that contributes to the unique taste and texture of corn tortillas. After the corn has soaked for the required length of time (depending on whether making nixtamal for masa or pozole), it's rinsed to remove the lime and then rubbed to remove the husks.

Mix lime and water in a large, non reactive (enamel or stainless steel) pot. Place pot over high heat and stir until lime is disolved. Add corn and, stiring occasionally, bring to a boil. If making nixtamal for masa to make tortillas, boil for a couple of minutes, remove from heat, cover and let soak overnight. If making nixtamal to make masa for tamales, boil for about 15 minutes, remove from heat, cover and let soak for a couple of hours. If making nixtamal for pozole, boil for 15 minutes and let soak for another 5 to 10 minutes. After soaking for the desired length of time, rinse the corn in a colander to remove all traces of the lime while rubbing the kernals to remove the softened hulls. Once cleaned, the nixtamal can then be ground into masa or left whole to be further simmered until tender to make hominy for pozole or menudo.

Making tortillas using fresh masa or masa harina...

Masa harina is fresh masa that's been dried and then ground into a flour-like consistency, to make masa harina you must first make masa. Masa harina is similar to, but not the same as, fine ground cornmeal. Trying to make corn tortillas out of regular cornmeal, even finely ground, would probably be unsatisfying. I suppose it would be possible to make nixtamal for tortillas, grind it into masa, dry it, grind it again and then re-hydrate it to make tortillas. But why not just make fresh masa from nixtamal and then make tortillas with it. Both nixtamal and masa can be frozen for later use.

If you wanted to be authentic, you could use a metate (a flat stone made from lava rock) and mano (sorta like a flattened, oval shaped rolling pin also made from lava rock) to grind the corn into masa...but a plate-style grain mill is a lot easier. My hand cranked Corona brand does double duty...I not only use it for masa but also for grinding grain, malted barley and other specialty malts for homebrewing. For tortilla dough, you need to adjust the plates for a fine grind to come up with a smooth dough that isn't grity. Tamales can be made from masa ground a little coarser allowing the use of a food processor if a plate mill isn't available. It might be possible to use a food processor for tortilla dough, but I doubt you would end up with the smooth continued in part 2

Related recipes